5 Common Problems with Mahindra 3650 (Solutions Included)

Mahindra tractors have a history of providing excellent value and are known for their durability. The 3650PST tractors come equipped with many luxury amenities that provide the operator with ultimate comfort and ease of operation.

But even the most durable models will have problems in the long run. Numerous difficulties plague the Mahindra 3650, including those with the vehicle’s engine, cooling system, electrical system, and high fuel consumption. These issues might hinder the capacity to perform efficiently and quickly.

However, I have chosen to discuss the five most common issues with a Mahindra 3650 PST, as well as their solutions. Below is a table listing the problems and quick solutions.

Problems and Solutions at a Glance:

Problems with Mahindra 3650Solutions
Roller Bearings Falling Out of The U-JointSteering column replacement
Leaking AntifreezeTighten the hoses, replace cracked hoses.
Issue With the CoolingClean air filter
More fuel consumptionClean clogged carburetor
Black Exhaust SmokeClean or replace the air filter;
Change fuel;

5 Most Common Problems with Mahindra 3650 and Their Possible Solutions:

You may experience Mahindra 3650 problems due to many reasons. Here are some of the reasons and how to solve them.

1. Roller Bearings Falling Out Of The U-Joint

When a u-joint starts to fail, it’s common to hear clunking when you change gears, grinding when you turn, or even vibrations when you’re going fast. If the bearing dries out, metal on metal contact is established, and the u-joint bearings start to squeal when the drive shaft turns.

Poor assembly of the components make the Bolts and pins came out everywhere

When a u-joint breaks, it stops your tractor from moving. This can cause a lot of damage.

The Fix:

Steering column replacement is necessary. Check for any other mechanical components that is worn or rusty fix them or replace them with new ones.

2. Leaking antifreeze

Problems with hydraulic leakage and leaky antifreeze have been observed on the Mahindra 3650.

Under your tractor, you may notice green puddles. When the temperature drops, coolant seeps from the Mahindra. Initially you may think the leaks from the water pump but it’s actually coolant that is leaking.

Leaking coolant might potentially harm interior parts as well. The following are some of the possible causes of the issue:

Bad thermostat, pump failure, operating at increased pressure, engine cylinder block clogged, problem with the inlet or outlet hose of the radiator, contaminated radiator finned pipes (due to filth, dust, soil, coolant corrosion/deposition etc.)

The Fix:

  • Install a new cap on the Radiator
  • Hoses with cracks should be replaced, and any that are too loose should be adjusted.
  • Repair a water pump that is leaking
  • Fix any radiator leak.

3. Issue With The Cooling

Mahindra 3650 have interior cooling issues. The AC do not work properly. The air conditioner produces a cool breeze, but it is not very powerful.

Even with the air conditioner cranking, the temperature inside the cab is around 20 degrees higher than outside. Some said it was intolerable to work with low performing AC systems.

The Fix:

Cleaning the air filter that may clogged with debris may fix this issue. Make sure nothing is jamming up the internal airflow. Evaporator may be clogged up with dust and other. Try cleaning it.  Servicing AC occasionally may help.

4. More Fuel Consumption

An excessive need for fuel is not a regular problem for tractors. Mahindra have records of high fuel consumption issue.

Unnecessarily high fuel consumption is typically caused by blocked carburetors. If the carburetor bowl vents are clogged, fuel will overflow and wet the spark plugs.

You should know how much fuel your tractor require. When there’s a problem, your tractor will consume much more fuel than usual.

The Fix:

Since the issue is strongly linked to carburetors, you need to inspect the carburetor to see if there is a problem. If cleaning do not fix the problem replace the carburetors.

5. Black exhaust smoke

If your Mahindra 3650 tractor is emitting black smoke from the exhaust, there may be a significant problem under the hood.

A clogged air filter may be at the root of the problem of black smoke. The primary causes are dirty air filter and use of wrong fuel.

The exhaust system is usually where the dark smoke comes from.

The Fix:

  • For a clogged or dirty filter, clean it properly or replace it if necessary.
  • Change the fuel brand and use the standard Mahindra suggested fuel.

What Majority of the Users Feel?

You can make a wise purchase decision by reading and considering the reviews, ratings, and comments of other customers who have purchased the same model.

Mahindra is a well-known company. Regarding the Mahindra 3650, people have a variety of thoughts. Many people are content with the way it functions, but many others are annoyed by the issues it presents.

One user remarked that Mahindra tractors tend to be reliable and straightforward. He has been using the 3650 model.

There are different opinions about Mahindra 3650. Many are satisfied with its functionality and many are frustrated with its problems.

Another customer reported he only used the Mahindra 3650 for four months before it broke after a year of usage and required extensive repairs.

Frequently Asked Questions

How many horsepower is a Mahindra 3650?

49 engine horsepower.

How much does a Mahindra 3650 weigh?

the Mahindra 3650 tractors weigh between 4620 and 5447 pounds.

How much does a Mahindra 3650 cost?

$34,990 USD.

Are Mahindra tractors good quality?

Yes, Mahindra tractors are considered to be reliable.

What is Mahindra PST?

Power shuttle transmission (PST).

Final Thoughts

As soon as you become aware of the issues with your Mahindra 3650PST, you will be able to easily resolve them. Keep in mind that frequent maintenance of tractor is essential to its smooth operation.

If you own a Mahindra Tractor and are having any problems, maybe this article will help you figure out what they are and how to solve them.

Related Posts:

Leave a Reply

Your email address will not be published. Required fields are marked *